Loading...
![Thumbnail Image](assets/images/Collection.png)
Theses
Browse
9 results
Search Results
ThesisItem Open Access Formulation of low fat beef burger with fat replacers(Department of Livestock Products Technology, College of Veterinary and Animal Sciences,Mannuthy, 2010) Govande Premanand, Laxmanrao; KAU; George Oommen, THealth conscious meat consumers prefer low fat meat products due to increasing incidents of high fat induced diseases. Manufacturing meat products with fat replacers (FR) enable to reduce fat and to alleviate the problems with the reduction of fat in products. Therefore, the present study was undertaken with the objectives of developing a palatable and economic formulary for low fat beef burger (LFBB) with carrageenan (CG), tapioca starch (TS), pregelatinised pork skin collagen (PSC) and their blends as FR and to assess its pH, cooking characteristics, proximate composition, nutritional value, textural and organoleptic qualities and shelf life under aerobic (AP) and vacuum packaging (VP) at 0-4oC and -20oC and its cost of production. Beef burgers (BB) are formulated at two different fat levels, viz., full fat (FF) 20 per cent and low fat (LF) 5 per cent as controls. Seven formulations of LFBB with 5 per cent fat are prepared with 0.5 per cent CG, 1.5 per cent TS, 2 per cent PSC and their blends, viz., CG-TS - 0.5% CG & 1.5% TS; CG-PSC - 0.5% CG & 2.0% PSC; TS-PSC - 1.5% TS & 2.0% PSC; CG-TS-PSC - 0.5% CG, 1.5% TS & 2.0% PSC as FR. BB are prepared as per the formularies with minced lean beef trimmings, tallow, salt, spices and condiments, rusk, ice flakes and FR. They are packaged aerobically in HDPE and in vacuum in polyethylene-polyamide (PEPA) pouches. pH, cook yield (CY), cook loss (CL), fat retention percentage (FRP), moisture retention percentage (MRP), dimensional shrinkage (DS), water holding capacity (WHC), Warner-Bratzler Shear Force (WBSF), Hunter L*, a*, b* colour values, proximate and mineral composition and nutritional value, purge loss (PL), Thiobarbituric Acid Reactive Substances (TBARS) value and sensory qualities are assessed on d 0, 10, 20 and 30 of storage at 0-4oC and -20oC or till spoilage, whichever is earlier. Six trials of the experiment were conducted. Cooking reduced the acidity of all the burgers. By the addition of FR a significantly (P< 0.05) very low acid cooked LFBB could be prepared. CY of burgers with CG-TS-PSC was significantly (P< 0.05) the highest with 85.84 per cent. LFBB with blends of FR significantly (P< 0.05) increased CY and correspondingly reduced CL. The DS in LFBB with CG-TS-PSC was significantly (P< 0.05) the lowest with 13.21 per cent. Addition of blends of FR holds water and fat in LFBB and reduces DS during cooking. FRP and MRP in CG-TS-PSC formulation was significantly (P< 0.05) the highest with 97.66 and 74.36 per cent, respectively due to blends of CG, TS and PSC. The WHC of LFBB with CG-TS-PSC was 95.36 per cent and WBSF value 5.30 N comparable to FF and the burgers were significantly (P< 0.05) most succulent, juicy and tender with the addition of blends of FR compared to tougher BB without FR. According to Hunter L*, a*, b* values, LFBB with blends of FR, especially CG-TS-PSC was lighter, less reddish (more bluish) and less yellowish (more greenish) and comparable to FF burger. Fat content in the beef trimmings and PSC were < 1.76 per cent. Cooking significantly (P< 0.05) reduced moisture content with a corresponding increase in the protein, fat, carbohydrate and ash. The percentage total calorific value of LFBB ranged from 6.36 to 7.18 of the Recommended Dietary Allowance (RDA). The contribution of fat to RDA of calorific value was from 2.22 to 2.42 per cent only, which was below the recommended 30 per cent. More than one third of the daily requirement of protein is obtained from 100g of LFBB. LFBB with FR are good sources of Na, K and P but not of Ca. Blends of FR in LFBB, especially CG-TS-PSC, were more efficient in significantly (P< 0.05) reducing PL and TBARS value on storage at 0-4oC for 10 days and at -20oC for 30 days in AP and VP. TBARS values were lower than the acceptable range of 1mg malonaldehyde/kg for oxidative rancidity. The low fat content and the presence of onion containing antioxidants in the formulary would have synergistically acted with CG in reducing the TBARS. On sensory evaluation on zero day, the LFBB with CG-TS-PSC scored significantly higher (P< 0.05) values of 7.00 and above for very good appearance and colour, very intense flavour, very desirable texture, juiciness, practically nil mouth coating and very acceptable overall acceptability similar to FF burger. But saltiness was very desirable than in FF. The LFBB with CG-TS-PSC in AP and VP retained all the sensory attributes and proximate composition even on storage. The very acceptable nature of CG-TS-PSC formulation might be due to the synergistic effect of fat replacers. The LFBB with 5 per cent fat and CG (0.5%), TS (1.5%), PSC (2%) and their blends as FR are developed economically with very acceptable overall acceptability, CY, nutritional quality, reduced PL and oxidative rancidity and shelf life up to 10 days at 0-4oC and 30 days at -20oC under AP and VP. The best LFBB with overall acceptability was CG-TS-PSC followed by CG-TS, CG-PSC, TS-PSC, PSC, CG and TS. Blends of FR are better than single FR, particularly CG-TS-PSC, as they increased CY, FRP, MRP, WHC, sensory attributes and decreased pH, CL, DS, WBSF, PL and TBARS. Further investigations with production of large quantities are required for calculation of cost of production at commercial scale.ThesisItem Open Access Standardisation of thermal processing of cuttle fish nidamental glant(Department of Processing Technology, College of Fisheries, Panangad, 2007) Bikash kumar Pati; KAU; Sherief, P MCuttlefish nidamental gland is a pair of flattened glands associated with the female reproductive system in cuttlefish. The glands are exported as a frozen product under the name cuttlefish roe. The procedure for thermal processing of cuttlefish nidamental gland in brine packed in tin plate can is standardised to produce a ready- to- eat product. The standardisation process essentially involved determination of optimum blanching conditions, retorting temperature, process time, processing parameters, optimum solid- liquid ratio and process levels to produce a safe product and assessment of quality changes during storage at room temperature. Cuttlefish nidamental gland in brine was packed in tin plate cans in 65 : 35 ratio (gland : brine) and thermal processed in an overpressure retort. The optimum blanching condition was found to be 5 % brine for 5 min. The retorting temperature and process time were selected as 121.10C and 25 min, respectively. The F0 value attained by the process was found to be 11.25 min with total process time of 30.54 min. The cook value meant to achieve tenderness of product was 81.54 min. The processed product was found to be commercially sterile. The product was acceptable even after 3 months of storage at room temperature with regard to all sensory attributes like appearance, colour, odour, taste, texture and overall acceptability. There were significant variation in the salt, pH and TBA values (P<0.05). The cut- out test showed a marginal increase in solid weight. The study showed that the cuttlefish nidamental gland can be used for processing ready to eat product, which can be stored at room temperature for long periods.ThesisItem Open Access Effect of phosphatic fertilizer compounds on aquatic primary production in saline water(Department of Fishery Hydrography, College of Fisheries, Panangad, 2005) Rajkumar, K R; KAU; Mrithunjayan, P SFish production in farms largely depends on the primary productivity In the water bodies. Among many factors, plant nutrient levels and their availability in absorbable forms for the plankton is the most important one contributing to primary production. The plant nutrient element, phosphorus often found to limit the production, mainly due to the behavior of phosphorus compounds to remain in unavailable form in aquatic environment. Hence it becomes imperative to supplement phosphorus in suitable chemical form to achieve better production. While the dosage is also important, the salinity of water bodies has an interactive effect. Thus species of compounds in phosphatic fertilizer is vital. In the present study, two types of phosphatic fertilizers and combination of these fertilizers with additives were tested for their effect on aquatic primary production. Synthetic fertilizer namely single superphosphate and natural phosphatic fertilizer namely rock phosphate were selected for study. Commercial grade trisodium phosphate was used as additive in combination with single superphosphate and rockphosphate in 1: 1 ratio with respect to phosphate- P. All the above four fertilizer materials were tested in brackishwater having two salinity levels, a low salinity level of approximately 10 ppt and a high salinity level of approximately 20 ppt. Each fertilizer was added in three different doses, ie, O.lppm, 0.2 ppm and 0.4 ppm of phosphate-P. A set of control with two salinity level of water and without adding fertilizer were also run. All the experiments were done in duplicate, in accordance with statistically designed 2x4x4 Factorial Completely Randomized Design. The experiments were conducted in wide mouth polythene drums having 25 litre capacity using 20 liters of water. The experiment was set up in a protected, undisturbed, elevated place and kept exposed to sun light for 30 days. Volume loss due to evaporation was compensated by adding appropriate amount of water having corresponding salinity. 140 Water samples were drawn on l " day (before the addition of fertilizer), i\ 14th and so" days and analysed for available phosphate, total phosphate, silicate, nitrite, nitrate, iron, water pH, dissolved oxygen, carbon dioxide, total alkalinity, total hardness and calcium. Productivity was assessed on 1 st day and so" day by estimating chlorophyll. The results were statistically analysed with ANOV A technique. In the experiment, maxrmum productivity in terms of chlorophyll (14.6mg/m3) was found under the treatment with single super phosphate along with additive trisodium phosphate when applied at a dose of 0.4 ppm of phosphate-P in the high saline media. For the same type of treatment in low salinity level, a little reduced value of productivity was observed (chloropyll =13.9 mg/rrr'), The next effective treatment was rock phosphate with trisodium phosphate at a concentration of 0.4 ppm of phosphate-P, here a chlorophyll concentration of 13.6mg/m3 and 12.6 mg/rrr' were obtained in high and low salinities respectively. The minimum productivity levels were observed in treatments with rock phosphate alone in all concentrations, compared to other treatments. It could be concluded from the experiments the following i) single super phosphate with a combination of trisodium phosphate was most effective compared to rock phosphate with trisodium phosphate, which could be due to the greater solubility of single super ph~sphate ii) single super phosphate was found to be more effective than rock phosphate, which could be due to the grater solubility as already explained. iii) the concentration level of 0.4 ppm of phosphate-P was found to be the most effective in enhancing the primary production compared to the lower doses tried ie, 0.1 and 0.2 ppm. iv) along with an increase in the available phosphate from the added fertilizers there was an increase in the primary production also v) salinity was found to have some effect on production, higher the salinity grater the production. This can be due to the availability of other minerals and intrinsic factors required for the synthesis of chlorophyll and biomass.ThesisItem Open Access Studies on the maturation and reproduction of pristolepis marginata jerdon under captive conditions(Department of Fishery Biology, College of Fisheries, Panangad, 2005) Nisha, Raj; KAU; Anna Mercy, T VPristolepis marginata Jerdon commonly called “Malabar catopra” or “Malabar sunfish” or “Chutichi” in the vernacular is an attractive ornamental fish belonging to the family Nandidae. This species, which is endemic to the Kerala part of Western Ghats inhabits clear and rapid streams. The species has been enlisted as vulnerable by – the Conservation Assessment and Mangement Plan Workshop (CAMP, 1998) for fresh water fishes of India held at NBFGR, Lucknow. Conservation of the endangered/vulnerable fishes cannot become successful without protection to the resources, which support the diversity and abundance. Hence Pristolepis marginata was one of the prioritized species for the development of captive breeding technology under NBFGR – NATP programme entitled “Germplasm inventory evaluation and gene banking of fresh water fishes of India”. Anna Mercy et al., (2003) developed the captive breeding technology for Pristolepis marginata. In the present study, an attempt was made to understand the maturation and reproduction of P. marginata in captivity. Captively reared fishes from the NATP project of College of Fisheries were utilized for the present study. A total of 209 fishes (12 to 149 mm) were used for the study of reproductive biology. A six-stage key was used for the classification of the maturity stages. The size at first maturity for females and females were found to be 54 mm and 72 mm SL respectively. Gross picture of distribution of ova stocks in the anterior, middle and posterior regions of the ovary remained almost the same except for the slight variation in the percentage composition of the mode. Based on the ova diameter frequency studies, P. marginata was found to be a multiple spawner, which release eggs in two or three batches. Absolute fecundity of the fishes ranged from 1102 (first time spawner) to 4965 (repeat spawner) in fishes of size range 66 to 80 mm SL. Number and size of eggs was found to be directly proportional to the size and age of the fish. Fecundity showed a positive linear relationship with the length and weight of the fish as well as to length and weight of the ovary. The reproductive organs of P. marginata were built on the usual percoid plan with paired ovaries and testis. The ovaries of P. marginata showed asynchronous development, in which oocytes at all the stages of development were present in the same ovary at the same time. During the spermatogenesis, there is a gradual decrease in size of different stages from spermatogonia to spermatozoans. Length – weight relationship values showed that the juveniles are exhibiting allometric growth pattern with ‘ b’ value equal to 2.83. Males also showed allometric growth pattern with ‘b’ value equal to 2.68. Females have shown isometric growth pattern with ‘b’ value equal to 2.94. Average relative condition factor values were higher in juvenile (1.43) due to the higher growth rate encountered during this stage of the life cycle. Males showed higher average relative condition value than females.ThesisItem Open Access Studies on temporal and spatial variations of circulation and hydrographic characteristics of Panangad region of the Vembanad Lake(Department of Fishery Hydrography, College of Fisheries, Panangad, 2003) Vijayakumar, C T; KAU; Varna, K KThe objective of the study was to find the seasonal and spatial variations of different hydrographical factors of the Vcmbanad Lake around Panangad region and compare the situation with that of the other parts of the lake. Salinity, temperature, current velocity and direction, dissolved oxygen, primary production and nutrients like phosphate, nitrite and nitrate were the parameters studied. For this monthly observations of these factors were made from nine stations located in and around Panangad region of Vembanad Lake. Beside this tidal cycle observations were carried out from two stations to study the tidal variation of the factors. S.T.D. meter was used to measure salinity, and temperature and a current meter for the current measurements. Water samples from surface and sub surfaces were collected with a clean bucket and a Van Dorn bottle. The estimation of dissolved oxygen, primary production and nutrients were done by standard methods. Marked seasonal fluctuation was noticed in the temperature of different stations. Annual variation showed two maxima. The temperature was minimum during southwest monsoon and maximum during pre monsoon months. In general, the vertical thermal stratification was small. The salinity exhibited marked seasonal fluctuation and generally the monsoon months recorded very low salinity values. After that there was an increase, reaching the maximum in pre monsoon months. Some vertical stratification was noticed during certain months. The Dissolved oxygen values were low during pre monsoon months and the content was more at surface than at the bottom layers. There was high seasonal fluctuation In the phosphate concentration. It showed high concentration during pre monsoon period. Generally bottom layers showed higher phosphate concentration than the surface layers. In the case of nitrite high values were observed durin 118 the monsoon and low values during dry season. Nitrate concentration also showed seasonal variation and high values were observed during the monsoon and low values during pre monsoon. The nutrient concentration was more in the inner smaller arms of the study area, in general. These inner arms were vertically homogenous also possibly due to higher mixing generated by the friction of the sides. In the tidal cycle observations it is found that salinity showed an increase during flood tide and decrease during ebb tide. At both stations considerable reduction in flood current speed was observed during post monsoon, compared to pre monsoon. During pre-rnonsoon a comparatively well mixed condition was prevailed. Post monsoon observations indicated very clear salinity stratification. This was due to the effect of freshwater discharge, which continued during this season though at reduced rate compared to monsoon season. It is found that the tidal effect on temperature was not well marked. It can be seen that different hydrographic factors of Panangad region of the Vembanad Lake exhibited much seasonal and spatial variations and the trend was in general, same to that shown by other parts of the lake.ThesisItem Open Access Community changes in zooplankton and macrobenthos of a prawn culture field in relation to hydrographical conditions(Department of Fishery Hydrography, College of Fisheries, Panangad, 2003) Shreeram Sudheer, Gubba; KAU; Cherian, C JThe present study was carried out in the prawn filtration field of the College of Fisheries at Panangad adjacent to the Cochin backwater system to find out the faunal variations of zooplankton and macrobenthos and to correlate them with the variations in hydro graphic conditions and compare the results with those obtained from the observations in the adjacent lake. Monthly samples for hydro graphical and biological studies were collected during the period from November 2002 to July 2003 from the culture field and adjacent backwater. Hydrographical features like temperature, salinity, transparency, pH, total alkalinity, dissolved oxygen, nitrate-N, phosphate-P, silicate-Si were observed. Crustacean larvae, copepods, tintinnids, nematodes, rotifers and veliger larvae of molluscs were the zooplankton groups obtained in the present study. Crustacean larvae and copepods were the dominant groups in both places and were found during all the months whereas tintinnids and nematodes were observed during saline period and their number decreased with decreasing salinity. Rotifers were recorded during low saline period only. Veliger larvae were recorded during December and February in the culture field, whereas, they were not present in the samples form the adjacent backwater. Statistical analysis for the influence of hydrographical parameters on the zooplankton showed that none of these had significant influence independently and the variations in the zooplankton abundance may be due to the combined effect of all these factors. Even though the seasonal changes in the total zooplankton were not pronounced the per cent composition of different groups showed fluctuation. Tanaidaceans, gastropods, polychaetes, amphipods, bivalves, isopods and chironomid larvae were the benthic groups obtained. Among these 112250 124 gastropods, tanaidaceans and polychaetes were the dominant forms. In the culture field benthic populations were maximum during the post-monsoon months and a showed a decreasing trend during pre-monsoon. With the onset of the monsoon they showed an increasing trend. In the backwater high benthic abundance was observed during January and February when high salinity prevailed and gradually decreased from March onwards reaching the minimum in July. In the culture field benthic abundance was mainly influenced by substratum characteristics and pH, whereas in the adjacent backwater salinity also played a role. The area of the present study is away from the barmouth and the nutrient levels especially phosphate is low in the culture field. This may be limiting the primary productivity of the area leading to low secondary production in terms of zooplankton and macrobenthos in the culture field. The high pH noticed in the culture field may be another reason for the low productivity.ThesisItem Open Access Development of a ready to consume sweetened fish powder for children(Department of Processing Technology, College of Fisheries,Panangad, 2004) Varghese John; KAU; Sherief, P MA sweetened snack food was developed from a lean and cheap fish (Priacanthus hamrur Forskal, 1775) for children, to meet their increased requirements for protein and energy, corresponding to their higher growth rate and physical activities. The food was planned to be attractive & palatable to children; without any fish flavour and bones; and that could be stored at room temperature. The product was developed from surimi, since the latter was devoid of all the undesirable characteristics of fish flesh but retained its nutritive qualities. Surimi was solubilized with salt, into a protein-sol and sweetened it with sucrose, which also had a protective effect on protein from heat-denaturation. The sol was dried, ground and flavoured with cocoa- powder. The most preferred levels of sucrose and cocoa-powder were standardized by sensory evaluation of samples prepared with different levels of sucrose and cocoa powder. The final product was prepared by the standardized procedure, packed in polyester-LDPE laminated pouches and stored. Children's response to [he product was also tested. A 90day's storage study was conducted and the quality changes during storage were monitored periodically. There were no significant variations in the pH and TVBN values (P>O.05). The moisture and TBARS values showed a statistically significant increase. A decreasing trend was observed in the aerobic plate counts. The sensory quality parameters like odour, texture, taste and overall acceptability, did not decrease significantly. The product was acceptable throughout the storage period.ThesisItem Open Access Growth and survival of penaeus monodon in monosex and mixed sex culture under laboratory condition(Department of Aquaculture, College of Fisheries, Panangad, 2008) Bajaniya Viralkumar, Chhaganlal; KAU; Mohanakumaran Nair, cSexual dimorphism is apparent in the black tiger shrimp, Penaeus monodon with females achieve larger size than the males. This character may be attributed to behavioral and/or physiological differences between the sexes. An experiment was developed to determine if there were advantages in rearing all female or all male P. monodon as opposed to mixed-sex populations. Juvenile shrimps (4.46±0.54 g) were collected from earthen pond and individually hand sexed and stocked in the circular cement tanks. Treatments all male, all female and mixed-sex were stocked @ 8 nos./tank. Each treatment had five replicates. The shrimps were offered commercial shrimp feed. The experiment was conducted for a period of 50 days. At harvest, all female shrimps had shown significantly higher growth than all male and mixed-sex treatment. Survival was not significantly different among treatments. FCR of all female was significantly lower than the all male and mixed-sex treatment. Result of the present study demonstrates a benefit to all female culture of P.monodon against the all male or mixed-sex culture. Thus culture of all female may be commercially more attractive to entrepreneurs. Although additional research is required to find a reliable and quick procedure for separation of the sexes or techniques for the production of all female populations.ThesisItem Open Access Molecular taxonomy of selected species of macrobrachium bate, 1868 (DECAPODA, PALAEMONIDAE) of Kerala waters(Department of Fishery Biology, College of Fisheries, Panangad, 2011) Jayaraj, G; KAU; Jayachandran, K VFreshwater prawns of the genus Macrobrachium are a conspicuous and important prawn constitute one of the most diverse, abundant and widespread crustacean genera. They are distributed in different water bodies of the tropical and subtropical regions of the world and comprises over 200 described species (Jayachandran, 2001). The palaenonids have taxonomically difficult groups because they appear to be morphologically higher conservative and also greater confusion among the evolutionary status. The present study was carried out both on morphological and molecular data to investigate the confirmation of species status and finding phylogenetic relationship of selected species of Macrobrachium in kerala waters. The species of M. canarae, M. idella, M. latimanus and M. scabriculum were collected from different water bodies of kerala, such as hill streams, rivers and brackish water. The four species inhabit varied habitats: M. latimanus is a hill stream prawn; M. canarae inhabits valleys without migration; M. idella and M. scabriculum inhabits lower stretches of river with estuarine migrations. These species were accurately identified based on morphology of earlier literature done by Jayachandran, 2001 and it shows variations within the individuals of M. idella. The use of DNA based methods to infer phylogenetic relationship can potentially overcome some of the difficulties encountered through the use of morphological characters. In molecular part, 16S rRNA and COI genes of mitochondrial DNA were analysed. Sequences of 16S rRNA and COI were obtained and submitted to NCBI. Based on sequence information, M. canarae shows few minor variations within the individuals. M. idella is shows significant variations within the two types of individuals. M. latimanus is shows separate clades of other country species. M. scabriculum is also shows significant variation with NCBI sequence of M. scabriculum. Phylogenetic relationship is clearly shows two types of M. idella based on NJ and MP tree. Hence, both morphological and molecular data is very effective for finding species variants and phylogeny.